Hot Rod Forum : Hotrodders Bulletin Board - Reply to Topic
Hotrodders.com -- Hot Rod Forum



Register FAQ Search Today's Posts Unanswered Posts Auto Escrow Insurance Auto Loans
Hot Rod Forum : Hotrodders Bulletin Board > Tech Help> Electrical> Alternator charging, then not charging
User Name
Password
lost password?   |   register now

Thread: Alternator charging, then not charging Reply to Thread
Title:
  
Message:
Trackback:
Send Trackbacks to (Separate multiple URLs with spaces) :

Register Now

In order to be able to post messages on the Hot Rod Forum : Hotrodders Bulletin Board forums, you must first register.
Please enter your desired user name (usually not your first and last name), your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-23-2011 07:29 AM
timothale
Tractor does it

I have a bosch alternator on my Case 580, I installed new brushes,very easy, but sometimes the battery would be dead. The diesel only uses a fuel solenoid so it will run a long time on a good battery if the lights are off. Sometimes i would get a charge the sometimes nothing, I took the alt into a repair shop and sometimes it charged and sometimes it didn't during the 2 minute test. The tech said there was a loose connection inside . $ 300 for a new alt. I just carry jumper cables and can go several days with no problem. I have a GM one wire to install as soon as I get Time.
07-23-2011 06:12 AM
EOD Guy I vote for a bad, or going bad, voltage reg.
07-22-2011 09:05 PM
corvette77
charging not charging

Belt tension is good, yes it is an internal regulator. I drove the car a bit farther distance this evening and the gauge fell to around 10volts and never came back. Just the last couple times I drove it, the gauge would fluctuate, tonight though, once it dropped down, it never came back up. I think you guys that mentioned the brushes may be correct. I'm going to take it in and have it tested and see what they tell me.
Thanks again
07-21-2011 02:41 AM
willowbilly3 loose belt maybe?
07-21-2011 12:41 AM
coupe66 I just bought myself a new regulator with brushes for my... eh, Volvo... And the way to see if the brushes are gone in that car is: all control-lamps in the instrument are on all the time!

/Pete
07-20-2011 06:50 PM
LATECH Worn brushes in the alternator, or intermittent regulator, more likely the first.
07-20-2011 06:45 PM
EOD Guy internal regulator?
07-20-2011 06:40 PM
corvette77
Alternator charging, then not charging

Shortly after starting the car, the alternator gauge drops to less than 12 volts and the idiot light comes on, then a minute later it's back up to almost 14 volts?
I have a new battery and I have tested both the battery (running & not running) as well as the alternator output while running. The battery tests out perfect but the alternator only shows about 13.4-13.6 volts after the motor has been running for a few minutes. Connections are tight and everything seems to work fine but the fluctuating gauge is what I can't figure out.
Thanks for any help.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -6. The time now is 03:27 PM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0 PL2
Copyright Hotrodders.com 1999 - 2012. All Rights Reserved.